Indian Journal of Science and Technology

Open Access Open Access  Restricted Access Subscription Access

Effect of Nematic Liquid Crystals on Optical Properties of Solvent Induced Phase Separated PDLC Composite Films


Affiliations
1 Department of Physics, Institute of Chemical Technology, Matunga, Mumbai 400019, India
2 Department of Physics, Guru Nanak College of Arts, Science and Commerce, Sion, Mumbai 400037, India
 

In the present article the effect of two different types of nematic liquid crystals on electro-optical and thermo-optical properties of polymer dispersed liquid crystal films are discussed. Composite films composed of polymer poly(methyl methacrylate) and two different nematic liquid crystals E7 and E8 were prepared by solvent induced phase separation technique. Scanning electron microscopy and polarizing optical microscopic results showed that liquid crystal phase is continuously embedded in a sponge-like polymer matrix. The domains of E7 were found slightly larger and more elongated than E8 under the same conditions of preparation. Variation of optical transmission properties of the composite films under the conditions of an externally applied alternating electric field (0-300 Vp-p, 50-1000 Hz) over a wide temperature range was studied using He-Ne laser (wavelength 632.8 nm) as a light source. The experimental results showed that the E7-polymer film has better electro-optical as well as thermo-optical properties as compared to the E8-polymer system. The performances of both the composites improved significantly with increasing temperature. It was found that the physical properties such as viscosity, refractive index and transition temperature of liquid crystals play a major role on the properties and behavior of the polymer dispersed liquid crystal composite films.

Keywords

Optical Materials, Electro-optical, Liquid Crystal, PDLC, Hysteresis
User

  • Baek S, Jeong Y, Kim HR, Lee SD and Lee B (2003) Electrically controllable In-Line-Type polarizer using polymer-dispersed liquid-crystal spliced optical fibres. Appl. Opt. 42, 5033-5039.

  • Bowley CC and Crawford GP (2000) Diffusion kinetics of formation of holographic polymer-dispersed liquid crystal display materials. Appl. Phys. Lett. 76, 2235-2237.

  • Buyuktanir EA, Glushchenko A, Wall B and West JL, Mitrokhin M and Holter B (2005) Flexible bistable smectic-A LCD on PDLC. Proc. SID, 36, 1778-1781.

  • Choi CH, Kim BK, Kikuchi H, Kajiyama T, Amaya N and Murata Y (1993) Electrooptical properties of poly(diisopropyl fumarate- co-styrene)/cyanobiphenyl-type liquid crystal composite films. J. Appl. Polym. Sci. 50, 2217-2222.

  • Coates D, Greenfield S, Sage IC and Smith G (1990) Liquid crystal mixtures for polymer matrix displays. Proc. SPIE. 1257, 37-45.

  • Deshmukh RR and Malik MK (2008a) Effects of the composition and nematic-isotropic phase transition on the electro-optical responses of unaligned polymer-dispersed liquid crystals. I. Composites of poly(methyl methacrylate) and E8. 108, 3063-3072.

  • Deshmukh RR and Malik MK (2008b) Effect of temperature on the optical and electro-optical properties of poly(methyl methacrylate)/ E7 polymer dispersed liquid crystal composites. J. Appl. Polym. Sci. 109, 627-637.

  • Doane JW (1990). In:, Liquid Crystals Applications and Uses, vol. 1 (ed Bahadur B), World Scientific, Singapore.

  • Drzaic PS (1988) Reorientation dynamics of polymer dispersed nematic liquid crystal films. Liq. Cryst. 3, 1543-1559.

  • Drzaic PS (1995). Liquid Crystal Dispersion. World Scientific, Singapore.

  • Drzaic PS and Muller A (1989) Droplet shape and reorientation fields in nematic droplet/polymer films, Liq. Cryst. 5, 1467-1475.

  • Han J (2003) Memory and depolarization effects of polymer-dispersed liquid crystal films based on E7/NOA61. J. Kor. Phys. Soc. 43, 45-50.

  • Han JW (2006) Study of memory effects in polymer dispersed liquid crystal films. J. Kor. Phys. Soc. 49, 1482-1487.

  • Jain SC, Thakur RS and Lakshmikumar ST (1993) Switching response of a polymer dispersed liquid crystal composite. J. Appl. Phys. 73, 3744-3748.

  • Kajiyama T, Miyamoto A, Kikuchi H and Morimura Y (1989) Aggregation states and electro-optical properties based on light scattering of polymer /(liquid crystal) composite films. Chem. Lett. 1989, 813-816.

  • Kajiyama T, Park K, Usui F, Kikuchi H and Takahara A (1993) Phase separated structure--electro-optical property relationships of polymer/liquid crystal composite film. Proc. SPIE 1911, 122-131.

  • Kalkar AK and Kunte VV (2002) Electro-optical studies on polymer dispersed liquid crystal composite films. II. Composites of PVB/E44 and PMMABA/E44. Mol. Cryst. Liq. Cryst. 383, 1-25.

  • Kalkar AK, Kunte VV and Bhamare SA (2008) Electrooptic studies on polymer-dispersed liquid-crystal composite films. III. Poly(methyl methacrylate-co-butyl acrylate)/E7 and poly(methyl methacrylate-co-butyl acrylate)/E8 composites. J. Appl. Polym. Sci. 107, 689-699.

  • Kalkar AK, Kunte VV and Deshpande AA (1999) Electro-optic studies on polymer-dispersed liquid-crystal composite films. I. Composites of PVB-E7. J. Appl. Polym. Sci. 74, 3485-3491.

  • Kayacan O, San SE and Okutan M (2007) Temperature dependency of phase transitions in polymer-dispersed nematic liquid crystal mediums. Physica A 377, 523-530.

  • Kim BK and Ok YS (1993) Effect of acrylonitrile content of styrene-co-acrynotirile (SAN) on morphology and electrooptical properties of polymer/liquid crystal composite films. J. Appl. Polym. Sci. 49, 1769-1775.

  • Lee SN, Sprunt S and Chien LC (2001) Morphology-dependent switching of polymer-stabilized cholesteric gratings. Liq. Cryst. 28, 637-641.

  • Lin YH, Ren H and Wu ST (2004) High contrast polymer-dispersed liquid crystal in a 90o twisted cell. Appl. Phys. Lett. 84, 4083-4085.

  • Liu J and Wu F (2005) Synthesis of photoisomeric azobenzene monomers and model compound effect on electric-optical properties in PDLC films. J. Appl. Polym. Sci. 97, 721-732.

  • Maier W and Saupe A (1960). Z. Naturforsch. A15, 287.

  • Maschke U, Coqueret X and Benmouna M (2002) Electro-optical properties of polymer dispersed liquid crystals. Macromol. Rapid Commun. 23, 159-170.

  • Montgomery Jr GP, West JL and Tamura-Lis W (1991) Light scattering from polymer-dispersed liquid crystal films: Droplet size effects. J. Appl. Phys. 69, 1605-1612.

  • Pan CY, Wang M, Bai R and Zou Y (1997) The effect of matrix composition on the electro-optical properties of polymer dispersed liquid crystal. Phys. Lett. A 234, 498-500.

  • Parab SS, Malik MK and Deshmukh RR (2012) Dielectric relaxation and electro-optical switching behavior of nematic liquid crystal dispersed in poly(methyl methacrytale). J. Non-Cryst. Solids. 358, 2713-2722..

  • Petti L, Mormille P and Blau WJ (2001) Experimental results on optical effects induced in epoxy resin based PDLC. Mol. Cryst. Liq. Cryst. 359, 53-65.

  • Pohl L and Merck E. (1990). In:, Liquid Crystals Applications and Uses, vol. 1 (ed Bahadur B), World Scientific, Singapore.

  • Ramanitra H, Chanclou P, Vinouze B and Dupont L (2003) Application of polymer dispersed liquid crystal (PDLC) nematic: optical fibre variable attenuator. Mol. Cryst. Liq. Cryst. 404, 57-73.

  • Reamey RH, Montoya W and Wong A (1992) Video-microscopy of NCAP films: the observation of LC droplets in real time. Proc. SPIE 1665, 2-7.

  • Ren H, Lin YH, Fan YH and Wu ST, (2005) Polarization-independent phase modulation using a polymer-dispersed liquid crystal. Appl. Phys. Lett. 86, 141110.

  • Ren Y, Petti L, Mormille P, Blau WJ (2001) Optically induced light modulation in epoxy-based polymer dispersed liquid crystals. J. Mod. Optics. 48, 1099-1112.

  • Senyuk BI, Smalyukh II and Lavrentovich OD (2005) Switchable two-dimensional gratings based on field-induced layer undulations in cholesteric liquid crystals. Opt. Lett. 30, 349-351.

  • Shen C and Kyu T (1995) Spinodals in a polymer dispersed liquid crystal. J. Chem. Phys. 102, 556-562.

  • Vaz NA and Montgomery GP (1987) Refractive indices of polymer-dispersed liquid-crystal film materials: Epoxy based systems. J. Appl. Phys. 62, 3161-3172.

  • Vaz NA, Smith GW, VanSteenkiste TH and Montgomery Jr. GP (1991) Droplet-size polydispersity in polymer-dispersed liquid- drystal films. Proc. SPIE 1455, 110-122.

  • Vicari L (1997) Electro-optic phase modulation by polymer dispersed liquid crystals. J. Appl. Phys. 81, 6612-6615.

  • Whitehead JB, Zumer S and Doane JW (1993) Light scattering from a dispersion of aligned nematic droplets. J. Appl. Phys. 73, 1057-1065.

  • Wu BG, Erdmann JH, and Doane JW (1989) Response times and voltages for PDLC light shutters. Liq. Cryst. 5, 1453-1465.

  • Wu BG, West JL, and Doane JW (1987) Angular discrimination of light transmission through polymer-dispersed liquid-crystal films. J. Appl. Phys. 62, 3925-3931.

  • Yang DK, Chien LC and Doane JW (1992) Cholesteric liquid crystal/polymer dispersion for haze-free light shutters. Appl. Phys. Lett. 60, 3102-3104.


Abstract Views: 597

PDF Views: 144




  • Effect of Nematic Liquid Crystals on Optical Properties of Solvent Induced Phase Separated PDLC Composite Films

Abstract Views: 597  |  PDF Views: 144

Authors

M. K. Malik
Department of Physics, Institute of Chemical Technology, Matunga, Mumbai 400019, India
P. G. Bhatia
Department of Physics, Guru Nanak College of Arts, Science and Commerce, Sion, Mumbai 400037, India
R. R. Deshmukh
Department of Physics, Institute of Chemical Technology, Matunga, Mumbai 400019, India

Abstract


In the present article the effect of two different types of nematic liquid crystals on electro-optical and thermo-optical properties of polymer dispersed liquid crystal films are discussed. Composite films composed of polymer poly(methyl methacrylate) and two different nematic liquid crystals E7 and E8 were prepared by solvent induced phase separation technique. Scanning electron microscopy and polarizing optical microscopic results showed that liquid crystal phase is continuously embedded in a sponge-like polymer matrix. The domains of E7 were found slightly larger and more elongated than E8 under the same conditions of preparation. Variation of optical transmission properties of the composite films under the conditions of an externally applied alternating electric field (0-300 Vp-p, 50-1000 Hz) over a wide temperature range was studied using He-Ne laser (wavelength 632.8 nm) as a light source. The experimental results showed that the E7-polymer film has better electro-optical as well as thermo-optical properties as compared to the E8-polymer system. The performances of both the composites improved significantly with increasing temperature. It was found that the physical properties such as viscosity, refractive index and transition temperature of liquid crystals play a major role on the properties and behavior of the polymer dispersed liquid crystal composite films.

Keywords


Optical Materials, Electro-optical, Liquid Crystal, PDLC, Hysteresis

References





DOI: https://doi.org/10.17485/ijst%2F2012%2Fv5i10%2F30924